Results 1 to 6 of 6

Coffman engine starter

Other Mechanical Systems Tech. Discuss Coffman engine starter in the Technical forums; I thought some of you might want to know what this type of starter was called and how it worked ...

  1. #1
    Pacific Historian syscom3's Avatar
    Join Date
    Jun 2005
    Location
    Orange County, CA
    Posts
    12,196
    Post Thanks / Like

    Coffman engine starter

    I thought some of you might want to know what this type of starter was called and how it worked
    The Coffman engine starter (also known as a "shotgun starter") was a starting system used on many radial piston engines in aircraft and armored vehicles of the 1930s and 1940s. Most American military aircraft and tanks which used radial engines were equipped with this system. A derivation of the Coffman starter was also used on a number of jet engines, including those used on the Canberra B-57 light bomber.



    The device used a blank gunpowder cartridge that, when fired, would cause the propeller to turn over and hopefully start the engine. The other systems used during the period were electric motors (such as those used in automobiles today) inertia starters (cranked either by hand or an electric motor) and compressed-air starters, which operate much like Coffman starters but are powered by pressurized tanks.

    Shotgun starters are composed of a breech and a motor, which are connected by a metal line. The cartridge fits into the breech, and is triggered either electrically or mechanically. The expanding gases from the cartridge pressurize the line and cause the motor to spin and engage the starter ring on the engine, which is attached to the crankshaft.

    The advantage of the cartridge system over electric starters is that the batteries of the time were weak and trouble-prone. Aircraft with electric motors often required the use of a battery cart and jumper cables, or large, heavy batteries carried in the plane. Inertia starters use a heavy wheel, usually made of brass, which is spun by a hand crank or electric motor, then the spinning wheel is made to engage the starter ring. The Coffman system weighs less.

    The primary disadvantages of the shotgun starter are the need to keep a stock of cartridges, one of which is used for each attempt to start, and the short time that the motor is spun by each cartridge. Compressed-air starters, which use the same type of motor, are usually recharged by an engine-driven compressor, negating the need to carry cartridges. Hybrid systems can be made simply by adding a cartridge breech or an air tank to an existing system.

    The Coffman starter was the most common brand of cartridge starters during the mid-1930s, and the name was used as a generic description. The starter became famous as a plot device in the movie The Flight of the Phoenix, when pilot James Stewart had a limited number of cartridges with which to start the makeshift aircraft's engine. (This was also featured in the 2004 remake of the film.)

    Some modern military diesel engines still use this device, but advances in battery technology have made shotgun starters obsolete for most uses.
    "Pilot to copilot..... what are those mountain goats doing up here in the clouds?"

  2. #2
    Senior Member
    Join Date
    May 2007
    Posts
    2,087
    Country
    Australia
    Post Thanks / Like

  3. #3
    “Archive” Micdrow's Avatar
    Join Date
    Aug 2006
    Location
    Wisconsin
    Posts
    6,402
    Country
    United States
    Post Thanks / Like
    Great write up there syscom3.

    "Valor does not mean Hero."

  4. #4
    Senior Member CRASHGATE3's Avatar
    Join Date
    Dec 2006
    Location
    Bomber county UK
    Posts
    208
    Country
    United Kingdom
    Post Thanks / Like
    This was taken in 2006 at Bruntingthorpe (where they have the Vulcan bomber and a couple of Lightnings )
    When they start an engine, even if you know, it still makes you jump...!
    Attached Thumbnails Attached Thumbnails Coffman engine starter-2006_0827bruntingthorpe20060055.jpg  

  5. #5
    Senior Member CRASHGATE3's Avatar
    Join Date
    Dec 2006
    Location
    Bomber county UK
    Posts
    208
    Country
    United Kingdom
    Post Thanks / Like
    From the Rolls Royce Avon Mk1 manual..
    Attached Thumbnails Attached Thumbnails Coffman engine starter-avon-starter.pdf  

  6. #6
    IP/Mech THE GREAT GAZOO FLYBOYJ's Avatar
    Join Date
    Apr 2005
    Location
    Colorado, USA
    Posts
    21,414
    Country
    United States
    Post Thanks / Like
    Quote Originally Posted by CRASHGATE3 View Post
    This was taken in 2006 at Bruntingthorpe (where they have the Vulcan bomber and a couple of Lightnings )
    When they start an engine, even if you know, it still makes you jump...!
    There was one flying in the states, came into Mojave - he told me those cartrages cost $60 a pop - back in 2000!

Bookmarks

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •  

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 101 102 103 104 105 106 107 108 109 110 111 112 113 114 115 116 117 118 119 120 121 122 123 124 125 126 127 128 129 130 131 132 133 134 135 136 137 138 139 140 141 142 143 144 145 146 147 148 149 150 151 152 153 154 155 156 157 158 159 160 161 162 163 164 165 166 167 168 169 170 171 172 173 174 175 176 177 178 179 180 181 182 183 184 185 186 187 188 189 190 191 192 193 194 195 196